Product ID:WELDWOOD VINYL FLOOR COVERING ADHESIVE 3076
MSDS Date:10/17/1986
FSC:8040
NIIN:00N011943
MSDS Number: BJHZP

DAP INC

5300 HUBERVILLE RD
DAYTON, OH 45401
US

Emergency Phone: 513-253-7154

Info Phone: 513-253-7154

Preparer: C J WARWICK

Cage: 90300

DAP INC.

277 DAYTON, OH 45401-0277 US

Telephone: 513-253-7154/800-543-3840

Cage: 90300

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <4%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYLENE GLYCOL (SARA III)

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: <2%

OSHA PEL C 50 PPM

ACGIH TLV: C 50 PPM,VAPOR; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:LIQ & VAP IRRIT EYES,SKIN,RESP
TRACT.MAY CAUSE CNS
DEPRESS,HDCH,DIZZ,FATIGUE,NAUSEA,UNCON.INGEST:CAUSES
NAUSEA,VOMIT,DIARRHEA,DEPRESSED RESP.OVEREXPOS BY INHAL IS UNLIKELY
SINCE VAP PRESS OF PRO D IS LOW.IF ASPIRATED, CAUSES
COUGHING,GAGGING,DISTRESS & RAPIDLY DEVELOPING PULMONARY EDEMA.(SEE
EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC:LIQ MAY CAUSE DERM AFTER
PRLNGD EXPOS TO SKIN.INGEST:EXCESS MAY LEAD TO RESP & CARDIAC
FAILURE & KIDNEY DAMAGE.NUMBER OF STUDIES INDICATED CONTINUAL
OVEREXPOS TO CONC SOLV VAPS OVER A PERIOD OF TIME MAY LEAD TO PERM
CNS DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
IMPAIRED PULMONARY FUNCTIONS AND KIDNEY DISORDERS.

First Aid:INHAL:REMOVE TO FRESH AIR,RESTORE BREATHING IF NECESSARY.GET
MD. EYES:FLUSH W/LGE AMTS OF WATER FOR 15 MIN.GET MD. SKIN:WASH
W/SOAP AND WATER. GET MD IF IRRITATION DEVELOPS. INGEST:DO NOT
INDUCE VOMIT ING. IF VICTIM IS CONSCIOUS, GIVE WATEROR MILK. GET MD
IMMEDIATELY.

Flash Point:NONE
Extinguishing Media:ANY AND ALL
Fire Fighting Procedures:DO NOT USE STRAIGHT HOSE WATER STREAM.WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT TO PROTECT
FROM COMBUSTION PRODUCTS.COOL EXPOSED CNTRS W/WATER
Unusual Fire/Explosion Hazard:CNTRS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN
FLAMES. DO NOT PUT IN CONTACT WITH OXIDIZING MATERIALS.

Spill Release Procedures:SMALL SPILL:USE ABSORBENT MATL OR SCRAPE UP
DIRED MATL & PLACE IN CNTRS.LGE SPILL:ELIM ALL SOURCES OF IGNIT &
VENTILATE SPILL AREA.CONTAIN BY DIKING TO PVNT SPREADING.ABSORB
W/SAND,EARTH,OIL DRY/OTHER ABSORB MATL/SHOVEL INTO CNTRS.(SEE SUPP
DATA)
Neutralizing Agent:SEE MATERIAL RELEASED/SPILLED ABOVE.

Handling and Storage Precautions:KEEP CNTRS FROM HEAT,FLAMES,DIRECT
SUNLIGHT.DO NOT STORE AT TEMPS ABOVE 120F.PROVIDE CROSS VENT IN
STOR AREA.KEEP CNTRS TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:CONTAINS FLAMMABLE SOLVENT.VAP HARMFUL & MAY CAUSE
FLASH FIRE.HARMFUL OR FATAL IF SWALLOWED.USE ONLY W/ADEQUATE VENT &
ELIMINATE SOURCES OF IGNIT WHEN PROD IS USED.AVOID PRLNGD/RPTD
BRTHG OF SOLVENT V APS & CNTCT W/SKIN.WASH CONTAM CLTHG.

Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED
FOR ANY COMPONENT, USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN. (CONSULT OSHA 29 CFR 1910.134)
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENT (LOCAL OR GENERAL
EXHAUST) TO MAINTAIN EXPOSURE BELOW PEL AND TLV.
Protective Gloves:SOLVENT IMPERVIOUS GLOVES FOR PRLNGD USE
Eye Protection:CHEMICAL WORKERS GOGGLES.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:CLEAN UP REMAINING SPILL BY WASHING W/NONFLAM SOLV
(1,1,1-TRICHLOROETHANE).PVNT RUN-OFF TO SEWERS,STREAMS,LAKES/OTHER
BODIES OF WATER.NOTIFY LOCAL HLTH/WILDLIFE OFFICIALS IF RUN-OFF
OCCURS. WEAR PROTECTIVE EQUIPMENT (SEE CONTROL MEASURES).

HCC:N1
Spec Gravity:1.24
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE MASTIC PASTE WITH NO STRONG ODOR
Percent Volatiles by Volume:30-40

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. CO*X,
NO*X

Waste Disposal Methods:DISCARDED SPILL RESIDUE MAY BE INCINERATED. DO
NOT INCINERATE SEALED CONTAINERS. DISPOSE I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS. LIQUIDS CANNOT BE DISPOSED OF IN A LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.